View RSS Feed

Technical Information

Functional and repair information

  1. Airbag (SRS) - Capacitor Replacement

    Introduction
    The Supplementary Restrain System (SRS) ECU suffers from ageing capacitors the same way as many other ECUs in the NSX. Two things makes it a special issue: The SRS is a safety device and a permanently lit warning light means failing the regular vehicle checks in most countries.
    Especially the first generation ECUs (cars with only a driver's Airbag) tend to fail by shorting an important MOS-FET inside the housing which complicates repairs.

    Diagnostic
    Due ...

    Updated 21-02-2021 at 03:49 PM by Heineken

    Categories
    Technical Information
  2. Speaker - Capacitor Replacement

    Introduction
    Each of the NSX's active speakers contain an amplifier module. Similar to most of the Electronic Control Units (ECUs) in the car, the capacitors in these modules tend to fail by leaking electrolyte. Especially the first generation of amplifiers (they can be identified by at least one small green capacitors) are known to leak early (sometimes after less then ten years) and resulting in most NSX having their amplifiers replaced at least once.
    Modules with heavy leakage may ...

    Updated 28-02-2021 at 01:19 PM by Heineken

    Categories
    Technical Information
  3. Speaker

    Introduction
    A number of sports cars from the 80s and 90s, were equipped with a BOSE audio system. A popular example, beside the NSX is the Corvette. These systems were specifically tuned to the vehicle to create the typical BOSE sound.

    Details
    Three specifically tuned amplifiers make up the system. Each one build into the speaker enclosures in the left door, right door and the passenger foot well. Door amplifiers are having six-pin connectors. The foot well amplifier additionally ...

    Updated 08-02-2021 at 09:10 PM by Heineken

    Categories
    Technical Information
  4. Airbag (SRS)

    Introduction
    Since its launch, the NSX was equipped with a driver's airbag. As of 1993 a passenger airbag and seat belt tensioners were added. The system is of rather simple design with the ECU containing an acceleration sensor that works together with two dash sensors and fires the airbag and seat tensioners upon front impact.

    ...

    Updated 12-02-2021 at 06:48 PM by Heineken

    Categories
    Technical Information
  5. Plastic Repair

    Introduction
    Broken-of plastics, especially mounting tabs on things like door cards (interior door cover), speaker mounting points and the defroster panel at the front window are to be expected considering the age of the NSX, especially after being overtightened. There are multiple ways to fix issues like these.

    ...

    Updated 02-01-2021 at 10:03 AM by Heineken

    Categories
    Technical Information
Page 1 of 3 123 LastLast